The Ultima electronic ignition kits are suitable for all 1970-1999 Harley-Davidson Evolution engines up to 140 cubic inches including turbocharged or supercharged motors.  Using the Dyna 2000i electronic ignition modules they feature intelligent protection along with short circuit protection for long life.  The advanced programming features enable suitability for a wide range of engines and builds.  In order to access the advanced programming features a separate programming kit including software and cables is needed and is available above to add to your kit.  The programming kit is NOT mandatory for use of the pre-programmed curves and features.  Pre-programmed into the device and selectable through DIP switches are 4 ignition curves, 4 rev limits, VOES selection, and dual fire or single fire mode.  The ignition module has the following advanced features accessible through the programming interface:

• 8 point fully definable wide open throttle curve
• 8 point fully definable part throttle curve
• Adjustable retard timing for turbo or supercharging
  
• Rev limit programmable in 50RPM steps
• Programmable dead cranking revs from 0-10
• Programmable rear cylinder offset from +/- 10 degrees
• Programmable rev limiter
• Intelligent overvoltage and undervoltage protection
  
• Separate programmable break-in rev limiter for new engines

The data recording features of the module are accessed through the programming interface and are as follows:

• Total engine hours
• Time at wide open throttle
• Number of engine starts
• Longest time operating at wide open throttle
• Maximum RPM
• Seconds near rev limit
• Statistical analysis of time at RPM
  

Programming kits are selectable to add to your kit above and include the following:

• Installation CD
• USB PC cable
• Programming link for ignition module
  

All kits feature high performance single fire ignition coils with high energy and very fast rise times.  The single fire coils allow independent timing control of the front and rear cylinders since each spark is independently controlled.  The 2.4 ohm resistance allows a very high energy output.  The coils will fit in the stock locations and under most coil covers.  The USA made high performance ignition coils are available individually as well and offer the following benefits:

• High energy, 45,000volts
• Fast rise times
• Low resistance, 2.4 ohms
• No break up at high RPM's
• Single fire
  

All kits contain high quality premium USA made plug wires.  The 8mm supression core wires feature the following benefits:

• Silicon and fiberglass outer braid provide superior abrasion resistance
• High quality silicone plug boots and coil boots
  
• 300 ohms resistance per foot
• Double insulated at plug and coil ends
• Resists temperature of up to 600 degrees Farenheit
• Up to 15 times more efficient than OEM wires
  

The typical high performance application will be for a single coil single fire ignition system like this.  However with the Dyna 2000i ignition module included in this kit it is possible to obtain different setups.  Single fire/single coil, single fire/dual coil, dual fire/single coil, and dual fire/dual coil are all available to be set up.  Below is a diagram of the single fire/single coil application this kit covers.  For the other applications please review the installation instructions below.





PDF Downloads